|
Sponsored Links (Register now to hide all advertisements) |
|
|
Thread Tools | Display Modes |
06-20-2014, 11:03 PM | #1 |
Member
Join Date: Sep 2013
Location: oklahoma
Posts: 38
|
electric fuel pump stops pumping
My wife grew impatient with my project 40 sedan so I bought another 40 as a driver. It's basically stock except for an electric fuel pump. The carb was rebuilt after I got it and I installed a Holley fuel regulator. Runs great! Until it gets hot. Not engine hot....just 20 minutes or so driving warm. Then the fuel pump stops pumping. I can wait ten minutes or so and it begins again. Any thoughts?? Thanks
|
06-21-2014, 01:04 AM | #2 |
Senior Member
Join Date: Oct 2012
Location: oroville calif.
Posts: 1,453
|
Re: electric fuel pump stops pumping
it sounds like you have a bad pump and its failing, either because its wore out or the voltage going to it is making it shut down, just like a coil that gets over heated because to much voltage, cools down and then works again, try a resister on the pump to drop voltage and see if will work more reliably
|
Sponsored Links (Register now to hide all advertisements) |
|
06-21-2014, 07:23 AM | #3 |
Senior Member
Join Date: May 2010
Location: Powell, TN
Posts: 2,509
|
Re: electric fuel pump stops pumping
Or the diaphram has turned to liquid rubber from alky gas.
|
06-21-2014, 07:28 AM | #4 |
Senior Member
Join Date: May 2010
Location: Florida and Penna.
Posts: 4,471
|
Re: electric fuel pump stops pumping
I think if the diaphragm went bad it wouldn't work at all. Check the voltage at the pump and make sure the pump is 6 volts if you have a 6 volt system. Are you sure it's fuel and not the coil? G.M.
__________________
www.fordcollector.com |
06-21-2014, 07:45 AM | #5 |
Senior Member
Join Date: May 2013
Location: Harrisonburg, VA
Posts: 842
|
Re: electric fuel pump stops pumping
I'm wondering if this is not the problem I'm having. 12 volt pump works fine at first. 2-3 lbs. pressure at the regulator pressure gauge. Run the truck for fifteen or twenty minutes and the pressure just seems to goes away. Maybe I've been replacing pumps I thought were bad and it's not the fault of the pump at all. I'll check the voltage at the pump and see what I come up with.
I don't mean to steal this thread Bart 40 but sounds like we have a similar problem. |
06-21-2014, 07:52 AM | #6 |
Senior Member
Join Date: May 2010
Location: Australia
Posts: 362
|
Re: electric fuel pump stops pumping
Sponsored Links (Register now to hide all advertisements)
|
06-21-2014, 11:16 AM | #7 |
Member
Join Date: Sep 2013
Location: oklahoma
Posts: 38
|
Re: electric fuel pump stops pumping
"I don't mean to steal this thread Bart 40 but sounds like we have a similar problem"
Steal away!!! I'm getting ready to go out and crawl under to try to see what's happening. Thanks to all who helped. |
06-21-2014, 11:23 AM | #8 |
Member
Join Date: Sep 2013
Location: oklahoma
Posts: 38
|
Re: electric fuel pump stops pumping
I don't think it's the coil. The last time this happened, I was staring at the engine (a large chunk of my mechanical knowledge) with the switch on and heard the pump come back on and watched fuel fill up the plastic fuel filter. I jumped back in,,,started it up and drove it home. Now my wife is afraid to ride in it again.
|
06-21-2014, 11:40 AM | #9 |
Senior Member
Join Date: May 2013
Location: Harrisonburg, VA
Posts: 842
|
Re: electric fuel pump stops pumping
Keep us posted if you find anything and I'll do the same if I find something on this end. Thanks
|
06-21-2014, 11:45 AM | #10 |
Senior Member
Join Date: Nov 2010
Location: NM
Posts: 2,438
|
Re: electric fuel pump stops pumping
Are these the Facet square pumps? I had one that behaved exactly like that. The pump just got hot internally and would swell or whatever, and the piston inside would lock up until it cooled.
__________________
'52 F-1, EAB flathead |
06-21-2014, 01:38 PM | #11 |
Senior Member
Join Date: May 2010
Posts: 875
|
Re: electric fuel pump stops pumping
If the pump is a high pressure pump it will need a return line to the tank. If so i would put it in the gas tank neck.
|
06-21-2014, 03:44 PM | #12 |
Member
Join Date: Sep 2013
Location: oklahoma
Posts: 38
|
Re: electric fuel pump stops pumping
Got waylayed.......I'll get under tomorrow. Thanks for all.
|
06-22-2014, 10:15 PM | #13 |
Member
Join Date: Sep 2013
Location: oklahoma
Posts: 38
|
Re: electric fuel pump stops pumping
I crawled under and didn't see any obvious problems. I did see that the electric pump is mounted a good two feet in front of the tank. Is that a problem? I think I have made up my mind to get a new pump but haven't decided which one yet.
|
|
|
Sponsored Links (Register now to hide all advertisements) |
|