|
Sponsored Links (Register now to hide all advertisements) |
|
|
Thread Tools | Display Modes |
09-14-2019, 07:59 PM | #1 |
Senior Member
Join Date: May 2010
Location: Raleigh, NC
Posts: 510
|
battery power loss mystery
I have a 6v NAPA commercial battery which I have maintained on a 6v maintainer charger...the battery is on the bench.
It has read 6.7v. for months; suddenly yesterday it read 4.3v. I unhooked it and let it sit a day and repowered it...still reading at 4.3v. What is going on ? Did the battery just drop a cell overnight? How would that happen? all suggestions welcome. thank you. |
09-14-2019, 08:07 PM | #2 |
Senior Member
Join Date: Jun 2017
Location: Walla Walla, WA
Posts: 1,045
|
Re: battery power loss mystery
Maybe the charger is at fault or the connection to the battery. I would check those first. Also, check the electrolyte in the battery cells.
|
Sponsored Links (Register now to hide all advertisements) |
|
09-14-2019, 09:38 PM | #3 |
Senior Member
Join Date: May 2010
Location: Largo Florida
Posts: 7,225
|
Re: battery power loss mystery
What does 'repowered it' mean ? If it means you recharged it, did the charger show full charge ? When on the charger does one cell bubble more than the others. It may be time to take a hydrometer reading. Have you checked to see if something is drawing down the battery ?
|
09-15-2019, 07:49 AM | #4 |
Senior Member
Join Date: Dec 2016
Location: Sunrise Beach, Mo
Posts: 439
|
Re: battery power loss mystery
No mention of the age of the battery. It appears you have one cell not taking a charge or ???? Your voltage is down just about one Cells worth. Older batteries due tend to fail!
|
09-15-2019, 08:50 AM | #5 |
Senior Member
Join Date: Aug 2017
Location: St. Maries, Idaho
Posts: 162
|
Re: battery power loss mystery
I just had to replace my battery for that same reason.
|
09-15-2019, 10:34 AM | #6 |
Senior Member
Join Date: May 2010
Location: Pine, AZ
Posts: 794
|
Re: battery power loss mystery
Sponsored Links (Register now to hide all advertisements)
|
09-15-2019, 04:46 PM | #7 |
Senior Member
Join Date: May 2010
Location: Raleigh, NC
Posts: 510
|
Re: battery power loss mystery
Patrick, "repowered" means I re-plugged the charger into the wall after disconnecting it for a day.
The battery is on the bench, so no draw down, cells are full and always have been, connections are clean, no sudden discharge. It just seems weird that overnight it went from 6.7v to 4.3v just sitting on my workbench. |
09-15-2019, 06:07 PM | #8 |
Senior Member
Join Date: May 2010
Location: Largo Florida
Posts: 7,225
|
Re: battery power loss mystery
OK, I didn't know the battery was sitting on the bench. I'd still check each cell with a hydrometer, but, it seems like a cell is bad and the battery is now defective.
|
09-16-2019, 07:28 AM | #9 |
Senior Member
Join Date: Aug 2011
Location: Eagle Bend, MN
Posts: 2,025
|
Re: battery power loss mystery
First off, try another charger for a few hours. If voltage comes back up, then there's a possibility it may still be ok. Chances are though, it likely needing replacement. Some maintainers run too high of a float but yours seems fine at 6.7V. I have had maintainers catch fire. However, I do run trickle chargers on batteries that sit unused a lot, although I hook them up for about 6 hours every few months, then disconnect them.
__________________
"There are some that can destroy an anvil with a teaspoon and shouldn't be allowed to touch anything resembling a tool." |
09-16-2019, 09:24 AM | #10 |
Senior Member
Join Date: Jun 2013
Location: Marana Arizona
Posts: 1,776
|
Re: battery power loss mystery
Use to be able to take batteries to an auto parts store and have them "load test" them for free. However many stores have gone digital and their fancy tool won't read a 6 volt battery. Hydrometer's are still available, even at Walmart or Amazon. Chap
https://www.walmart.com/search/?cat_...ery+hydrometer |
09-16-2019, 09:30 AM | #11 |
Senior Member
Join Date: Jan 2019
Location: Florida Panhandle
Posts: 585
|
Re: battery power loss mystery
The low cost hydrometer test is the way to go. Suspect one cell will show less floating balls than the rest which will indicate a bad cell.
|
|
|
Sponsored Links (Register now to hide all advertisements) |
|