The Ford Barn - Speedometer suddenly quit

The Ford Barn (https://www.fordbarn.com/forum/index.php)

- Model A (1928-31) (https://www.fordbarn.com/forum/forumdisplay.php?f=3)

- - Speedometer suddenly quit (https://www.fordbarn.com/forum/showthread.php?t=113369)

Hioridge

08-01-2013 06:18 AM

Speedometer suddenly quit

The speedometer suddenly quit working last night It has been "bouncing" some, but otherwise OK. What do you think is the probable problem?
Please tell me it will be easy to fix.
Thanks

papanick

08-01-2013 06:30 AM

Re: Speedometer suddenly quit

I would check the cable first. If that is good then It would be in the speedometer. papanick

Tom Wesenberg

08-01-2013 07:27 AM

Re: Speedometer suddenly quit

I would unscrew the cable from the speedometer and make sure the speedometer turns freely.
Be sure the cable has no kinks and is well lubed.

Hioridge

08-01-2013 07:30 AM

Re: Speedometer suddenly quit

What's the best way to check the cable?
Unhook from transmission and see if the cable pulls out of the sheath?

Tom Wesenberg

08-01-2013 08:13 AM

Re: Speedometer suddenly quit

You'll probably find the cable needs to be removed from the top end.
Just look at the cable and housing for kninks or frayed/broken strands.

Ron/IA

08-01-2013 09:09 AM

Re: Speedometer suddenly quit

Hioridge - My speedo suddenly quite. I unscrewed the cable sheath from the bottom of the transmission, pulled on the cable inside it, and it came out. The cable twisted into two pieces. This would be a quick check.

If that's not it; Tom is correct the cable sheath needs to be removed at the speedo to remove the cable.

My speedo became increasingly hard to turn and twisted the cable. I repaired the speedo by using instructions I found. Removed all the old grease, and lubricated all bearing and gear surfaces. Caution - the speedo must turn VERY freely to operate properly and not continue to twist the cable. (I had to buy another cable because I had not freed it up enough.) It takes a lot of cleaning and lubing (and time) to get the speedo to spin freely.

There are numerous speedo repairers, and they are very good at what they do.

Good luck,
Ron/IA

Hioridge

08-08-2013 05:04 PM

Re: Speedometer suddenly quit

Thanks guys fro your help. The cable was bad and Tam's fixed me up with a new one. I'm puttering around again!

160B	08-08-2013 05:14 PM

Re: Speedometer suddenly quit

Quote:

Originally Posted by Hioridge (Post 703022)

Thanks guys fro your help. The cable was bad and Tam's fixed me up with a new one. I'm puttering around again!

The cause of the failure of the cable is the speedometer is becoming harder to turn internally. Until you service the speedometer head you will continue to have cable failures due to the problem in the speedometer head.

Fred K-OR

08-08-2013 05:31 PM

Re: Speedometer suddenly quit

Quote:

Originally Posted by 160B (Post 703027)

This is good advise. Make sure the speedo is turning easy. And the only way to do that is to take it loose from the top at the speedo. I had same problem because my speedo was not moving easy and it broke the cable.

All times are GMT -5. The time now is 01:27 PM.