|
Sponsored Links (Register now to hide all advertisements) |
|
|
Thread Tools | Display Modes |
05-03-2011, 08:08 PM | #1 |
Senior Member
Join Date: Jul 2010
Location: Palm City FL>
Posts: 556
|
Flathead electric fuel pump
My flathead powered 32 has fuel problems after I run it a couple hours in the florida heat. I just sent away for an electric fuel pump should I run it through the mechanical pump, or bypass the original pump and plumb it directly to the carbs? Thanks Rich.
|
05-03-2011, 08:34 PM | #2 |
Senior Member
Join Date: Dec 2010
Location: Port St Lucie Florida
Posts: 398
|
Re: Flathead electric fuel pump
I had one on My 40 Pickup for years (remove or cut 1" off top of push rod ) ran through mechanical pump to keep engine looks-some say it acts as a pressure regulator?? Recommend hook up pump on switch seperate of ignition so you can shut off & run Carb dry for short or long storage. My 36 will get same treatment for florida heat--Also sent Coil & Water Pumps to "Skip" for same reason. The pump I use is the Airtec E8902 6v-delivers 3.5-4 psi Good luck
|
Sponsored Links (Register now to hide all advertisements) |
|
05-04-2011, 12:05 AM | #3 |
Senior Member
Join Date: May 2010
Location: Wa.
Posts: 5,408
|
Re: Flathead electric fuel pump
Good plan to put a rollover/inertia switch in the power lead to the pump.
Shuts the pump off if you get bumped real hard or roll over. |
05-04-2011, 05:58 AM | #4 |
Senior Member
Join Date: Jun 2010
Location: Skaneateles,NY(summer)/Port St.Lucie,FL(winter
Posts: 126
|
Re: Flathead electric fuel pump
Leave your fuel pump hooked up/working, and install a 6V flow through type electric. I got mine from Sacramento Ford and have a toggle switch under the dash. Key on, switch on, and let the pump fill the carb, rather than using the starter to do it. Fires right up, then switch off. When idleing, or in the blazing sun, hit the switch...prevents vapor lock, and the pump is low enough pressure so that it won't overpower the carb float if you prefer to leave it on...or forget...
__________________
..."If my calculations are correct, when this baby hits eighty-eight miles per hour... you're gonna see some serious shit"... |
05-04-2011, 09:43 AM | #5 |
Senior Member
Join Date: May 2010
Location: Colorado
Posts: 1,264
|
Re: Flathead electric fuel pump
I agree, I have one on my truck. Use it to prime or help with vapor lock. Works very well with the pump. I also got gaskets for the pump from Ken.
|
05-04-2011, 10:02 AM | #6 |
Senior Member
Join Date: May 2010
Location: Wilmington, OH/Lakeland, FL
Posts: 951
|
Re: Flathead electric fuel pump
Sponsored Links (Register now to hide all advertisements)
go. Another thought....I noticed an article in Hemmings this month that lists a website for gas stations that sell pure gasoline instead of the ethanol added gasoline. The ethanol gasoline has a lower boiling point than pure gasoline. Would probably help to keep you away from vapor lock. Pat |
05-04-2011, 10:20 AM | #7 |
Senior Member
Join Date: May 2010
Location: BIRTHPLACE OF SPEED, FLORIDA
Posts: 531
|
Re: Flathead electric fuel pump
Depending on the pressure output of the electric pump it may over pressure the carb. You may need a pressure regulator to prevent that problem,
|
05-07-2011, 11:07 AM | #8 |
Senior Member
Join Date: Jul 2010
Location: Ventura, CA
Posts: 2,464
|
Re: Flathead electric fuel pump
I have been running electric fuel pumps as a supplemental backup to aid in starting and/or overcome a vapor lock for over fifty years, on various makes and models of vehicles.
It is always best to locate the pump as close to the tank as possible, electric pumps push better than they pull. When purchasing an electric pump you have to make sure that the electric pump is the type that a mechanical pump can draw fuel through. The engineer types will tell you that you need some kind of a pump kill switch, in the event that the vehicle is in an accident, however, if you are only using the electric pump to avoid a vapor lock or as a starting aid, oil pressure switches defeat the purpose of the pump because you have to crank the engine over to get oil pressure to trip the switch. If everything in the carb is working correctly and you turn the electric pump on to prime the system on a vehicle that has been sitting for awhile, the pump will run until the fuel system is pressurized, then the electric pump will shut down. If the electric pumps keeps running the fuel system is not pressurized, a stuck float valve, etc., is usually the problem. Some people like to plumb electric pumps so they are in a bye-pass loop around the mechanical pump. I think that the bye-pass plumbing requires a check valve to prevent the fuel from being pumped back into the tank.
__________________
Bill.... 36 5 win cpe |
05-07-2011, 05:33 PM | #9 |
Member
Join Date: May 2010
Location: Henderson,NV
Posts: 56
|
Re: Flathead electric fuel pump
If you run your electric fuel pump through the stock mechanical it is possible in case of a diaphram rupture in the mechanical to fill your crankcase with fuel.
Les Bliss |
05-07-2011, 06:05 PM | #10 |
Senior Member
Join Date: May 2010
Location: pittsfield, MA
Posts: 2,086
|
Re: Flathead electric fuel pump
Rich,
You said your car has "fuel problems" after a few hours of Florida heat but don't describe what they are or why you think an electric pump is required. When you have this "problem" you should take off the air cleaner and look down the throat to see if when you depress the throttle you get a squirt of out from the accelerator pump. If so, I don't think you have a fuel problem or "vapor lock" but maybe an overheated coil that will work fine after a little cooling off. So, could you describe your fuel problem? Maybe you are wasting time and $$ on the electric pump. John |
05-08-2011, 07:13 PM | #11 |
Senior Member
Join Date: Jul 2010
Location: Palm City FL>
Posts: 556
|
Re: Flathead electric fuel pump
John: It is definitely a fuel problem I can usually keep it runnung by pumping the gas pedal. The second stromberg is on a progressive linkage and holds anough gas to get me to a safe spot to let it simmer down not a pretty sight and downright embarrising at times. I know what you are saying,, one of m flathead buddies says" Most ignition problems turn out to be fuel, and most fuel problems usually turn out to be ignition"! Rich
|
06-28-2015, 02:01 PM | #12 |
Junior Member
Join Date: Dec 2014
Posts: 13
|
Re: Flathead electric fuel pump
I'm running a electric pump back by my tank pushing fuel thru the mechanical pump because the cam lobe for my pump rod is worn out. Is there anything I can do to the mechanical fuel pump to make it flow better since there isn't a rod inside it and not working any longer? I'm trying to keep it looking original. Ohhh it's on a stock single carb 59A-B.
|
06-28-2015, 02:06 PM | #13 |
Senior Member
Join Date: Nov 2010
Location: NM
Posts: 2,438
|
Re: Flathead electric fuel pump
If you are going to have an electric pump, why run the gas thru the old fuel pump where it does nothing but pick up heat?
__________________
'52 F-1, EAB flathead |
06-28-2015, 02:06 PM | #14 |
Junior Member
Join Date: Dec 2014
Posts: 13
|
Re: Flathead electric fuel pump
Here's my setup in my 36 5window.
|
06-28-2015, 02:07 PM | #15 |
Senior Member
Join Date: Nov 2010
Location: NM
Posts: 2,438
|
Re: Flathead electric fuel pump
Those round Spectre pressure regulators are junk IMO.
__________________
'52 F-1, EAB flathead |
06-28-2015, 02:08 PM | #16 |
Senior Member
Join Date: Jun 2014
Location: New Jersey
Posts: 1,772
|
Re: Flathead electric fuel pump
I have never done this but I understand you can weld a nub on rod to give it the hight you need- in also heard old timers would insert a small washer in the cup of the mech pump
|
06-28-2015, 02:08 PM | #17 |
Junior Member
Join Date: Dec 2014
Posts: 13
|
Re: Flathead electric fuel pump
|
06-28-2015, 02:09 PM | #18 |
Junior Member
Join Date: Dec 2014
Posts: 13
|
Re: Flathead electric fuel pump
|
06-28-2015, 02:12 PM | #19 |
Junior Member
Join Date: Dec 2014
Posts: 13
|
Re: Flathead electric fuel pump
|
06-28-2015, 03:13 PM | #20 |
Senior Member
Join Date: May 2010
Location: Ft Mohave,Az
Posts: 1,987
|
Re: Flathead electric fuel pump
|
|
|
Sponsored Links (Register now to hide all advertisements) |
|